Yaskawa JUSP-NS500 由直流電機驅動控制電路框圖可以看出驅動控制電路結構簡單，主要由四部分電路構成，其中光電隔離電路較簡單，在此不再介紹，下面對直流電機驅動控制電路的其他部分進行詳細介紹。
4.1 H橋驅動電路設計
在直流電機控制中常用H橋電路作為驅動器的功率驅動電路。由于功率MOSFET是壓控元件，具有輸入阻抗大、開關速度快、無二次擊穿現象等特點，滿足高速開關動作需求，因此常用功率MOSFET構成H橋電路的橋臂。H橋電路中的4個功率MOSFET分別采用N溝道型和P溝道型，而P溝道功率MOSFET一般不用于下橋臂驅動電機，這樣就有兩種可行方案：一種是上下橋臂分別用2個P溝道功率MOSFET和2個N溝道功率MOSFET；另一種是上下橋臂均用N溝道功率MOSFET。
相對來說，利用2個N溝道功率MOSFET和2個P溝道功率MOSFET驅動電機的方案，控制電路簡單、成本低。但由于加工工藝的原因，P溝道功率MOSFET的性能要比N溝道功率MOSFET的差，且驅動電流小，多用于功率較小的驅動電路中。而N溝道功率MOSFET，一方面載流子的遷移率較高、頻率響應較好、跨導較大；另一方面能增大導通電流、減小導通電阻、降低成本，減小面積。綜合考慮系統功率、可靠性要求，以及N溝道功率MOSFET的優點，本設計采用4個相同的N溝道功率MOSFET的H橋電路，具備較好的性能和較高的可靠性，并具有較大的驅動電流。其電路圖如圖3所示。圖中Vm為電機電源電壓，4個二極管為續流二極管，輸出端并聯一只小電容C6，用于降低感性元件電機產生的尖峰電壓。
4.2 電荷泵電路設計
電荷泵的基本原理是通過電容對電荷的積累效應而產生高壓，使電流由低電勢流向高電勢。最早的理想電荷泵模型是J.Dickson在1976年提出的，當時這種電路是為可擦寫EPROM提供所需電壓。后來J.Witters，Toru Tranzawa等人對J.Dickson的電荷泵模型進行改進，提出了比較精確的理論模型，并通過實驗加以證實提出了相關理論公式。隨著集成電路的不斷發展，基于低功耗、低成本的考慮，電荷泵在電路設計中的應用越來越廣泛。
簡單電荷泵原理電路圖如圖4所示。電容C1的A端通過二極管D1接Vcc，電容C1的B端接振幅Vin的方波。當B點電位為0時，D1導通，Vcc開始對電容C1充電，直到節點A的電位達到Vcc；當B點電位上升至高電平Vin時，因為電容兩端電壓不能突變，此時A點電位上升為Vcc+Vin。所以，A點的電壓就是一個方波，值是Vcc+Vin，最小值是Vcc（假設二極管為理想二極管）。A點的方波經過簡單的整流濾波，可提供高于Vcc的電壓。
在驅動控制電路中，H橋由4個N溝道功率MOSFET組成。若要控制各個MOSFET，各MOSFET的門極電壓必須足夠高于柵極電壓。通常要使MOSFET完全可靠導通，其門極電壓一般在10 V以上，即VCS＞10 V。對于H橋下橋臂，直接施加10 V以上的電壓即可使其導通；而對于上橋臂的2個MOSFET，要使VGS＞10 V，就必須滿足VG＞Vm+10 V，即驅動電路必須能提供高于電源電壓的電壓，這就要求驅動電路中增設升壓電路，提供高于柵極10 V的電壓。考慮到VGS有上限要求，一般MOSFET導通時VGS為10 V～15 V，也就是控制門極電壓隨柵極電壓的變化而變化，即為浮動柵驅動。因此在驅動控制電路中設計電荷泵電路，用于提供高于Vm的電壓Vh，驅動功率管的導通。其電路原理圖如圖5所示。
電路中A部分是方波發生電路，由RC與反相施密特觸發器構成，產生振幅為Vin=5 V的方波。B部分是電荷泵電路，由三階電荷泵構成。當a點為低電平時，二極管D1導通電容C1充電，使b點電壓Vb=Vm-Vtn；當a點為高電平時，由于電容C1電壓不能突變，故b點電壓Vb=Vm+Vin-Vtn，此時二極管D2導通，電容C3充電，使c點電壓Vx=Vm+Vin-2Vtn；當a點再為低電平時，二極管D1、D3導通，分別對電容C1、C2充電，使得d點電壓Vd=Vm+Vin-3Vtn；當a點再為高電平時，由于電容C2電壓不能突變，故d點電壓變為Vd=Vm+2Vin-3Vtn，此時二極管D2、D4導通，分別對電容C3、c4充電，使e點電壓Ve=Vm+2Vin-4Vtn。這樣如此循環，便在g點得到比Vm高的電壓Vh=Vm+3Vin-6tn=Vm+11.4 V。其中Vm為二極管壓降，一般取0.6 V。從而保證H橋的上臂完全導通。
Yaskawa JUSP-NS500 華銳SL1500/77風機備品備件
華銳SL1500/82型風機備品備件
風機機型華銳SL1500/82
新疆金風GW77/1500 型風力發電機組
新疆金風S50/750 風力發電機組
3MW風力發電機 3MW風機機艙柜
SCS溫度模塊 PTAI 216：bachmann XE82風機
模擬量輸入/輸出模塊 AIO288廠家：bachmann：適用于XE82風機
FL1500風機
金風1.5MW風機
數字量輸入/輸出模塊 DIO280 數量1
SCS溫度模塊 Bachmann PTAI 216 數量1
CAN總線從模塊CS200/N 內帶ISI222、AIO288、DIO248的驅動程序以及和CM202的通訊程序
編碼器接口模塊 ISI222 數量1
全新原裝華銳風機 WTCBA200A crowbar 正品保障windtec
2 主控制器WT98 ABB/WT98 07KT98 個 1 3
主控制器WT97 ABB/WT97 07KT97 個 1
4 巴赫曼PLC（塔基） 整套 個 1
5 PLC-電源模塊 24VDC/68W NT255 個 1
6 PLC-中央處理器模塊 128MB MPC240 個 1
ABB YB560103-CB DSQC236B DriveUnit
ABB YB560103-CC DSQC236C DriveUnit
ABB 3HAB2207-1 DSQC236D DriveUnit
ABB YB560103-CD DSQC236G DriveUnit
ABB 3HAB2207-1 DSQC236P DriveUnit
ABB YB560103-CE DSQC236T DriveUnit
ABB YB560 103-CL/5 DSQC241 PowerUnit
ABB 3HAB 2210-1 DSQC300 Robot Computer
ABB 3HAB 2216-1 DSQC314B PowerUnit
ABB 3HAB 2219-1 DSQC316 Main Computer
ABB 3HAB 2220-1 DSQC317 6MB Card
ABB 3HAB 2236-1 DSQC321 4MB Card
ABB 3HAB 5956-1 DSQC323 8MB Card
ABB 3HAB 5957-1 DSQC324 16MB Card
ABB 3HAB 2241-1 DSQC325 Main Computer
ABB 3HAB 2242-1 DSQC326 Robot Computer
ABB 3HAB7229-1 DSQC328 I/O Card
ABB 3HAB 6182-1 DSQC335 Robot Computer
ABB 3HAB8101-3/05D DSQC345B DriveUnit
ABB 3HAB8101-3/08C DSQC345C DriveUnit
ABB 3HAB8101-7/01C DSQC346C DriveUnit
ABB 3HAB8101-8 DSQC346G DriveUnit
ABB cable DSQC351 Interbus-S
ABB 3HAC 0373-1 DSQC361 Main Computer
ABB 3HAC3180-1 DSQC373 Robot Computer
ABB 900054 1Gb SD-card S3/S4 DDR
ABB 900056 1Gb SD-card S2 DDR
3HNE 00026 Teach Pendant
3HNE 00312-1 Teach Pendant
3HNE 00313 Teach Pendant
CHAA 3560-AXA Teach Pendant
ABB 3HAB9271-1/01B DriveUnit Dummy DriveUnit Dummy
ABB 57510001-AA DSCA 114 Print out board
ABB 57520001-U DSCA 121 Communication board
ABB 57160001-A DSDI 110 Digital input board
ABB 57160001-K DSDO 110 Digital output board
ABB YB161102-AH DSDX 110 Digital in/output board
ABB 57160001-TP DSDX B001 digital in-output board
ABB 57360001-U DSMB 124 Semiconductor memory board
ABB 57360001-AN DSMB 125 Semiconductor memory board
ABB 57360001-HG DSMB 127 Memory board
ABB 57330001-N DSMC 110 Floppy disk controller
ABB YB161102-AK DSPA 110 Axis computer
ABB 57310256-AF DSPC 150 Central processor
ABB 57310256-BA DSPC 153 Expand. single board computer
ABB 57310001-GP DSPC 157 Expand. single board computer
ABB YB161102-AD DSQC 103 Resolver power board
ABB YB161102-AF DSQC 105 Display board
ABB YB161102-BA DSQC 110 Programming board
ABB YB161102-BS DSQC 115 Resolver power board + 2 analogue
ABB YB161102-BE DSQC 116 Power supply
ABB YB161102-BG DSQC 117 Resolver power board
ABB YB161102-BU DSQC 124 Terminal unit
ABB YB161102-BV DSQC 129 R/D board
ABB YB161102-CH DSQC 136 Safety board
ABB YB161102-CM DSQC 138 Terminal unit
ABB YB560103-AC DSQC 202 Robot computer
ABB YB560103-AS DSQC 208A External axis board
ABB YB560103-AL DSQC 209 Analogue I/O board
ABB YB560103-AM DSQC 210 Safety board
ABB YB560103-AN DSQC 211 Power supply
ABB YB560103-BF DSQC 215 Robot computer
ABB YB560103-AZ DSQC 220 Programming board
ABB YB560103-BD DSQC 223 PC Board digital I/O
ABB YB560103-BE DSQC 224 PC Board combi I/O
ABB YB560103-BK DSQC 227 Winchester interface
ABB YB560103-BD DSQC 228 Safety board
ABB YB560103-BN DSQC 230 Robot computer
ABB YB560103-BS DSQC 233 External axis board
ABB YB560103-BY DSQC 235A Rectifier
ABB YB560103-BZ DSQC 235B Rectifier
ABB YB560103-CA DSQC 236A Drive unit
DSQC 236B Drive
ABB YB560103-CC DSQC 236C Drive unit
ABB 3HAB2207-1 DSQC 236D Drive unit
ABB YB560103-CD DSQC 236G Drive unit
ABB 3HAB2245-1 DSQC 236H Drive unit
ABB 3HAA3563-AJA DSQC 236P Drive unit
ABB YB560103-CE DSQC 236T Drive unit
DSQC 239 Board - ABB RIO
ABB DSQC 241 Power supply
ABB YB560103-CM DSQC 242 Programming board
ABB 3HAA0001-CP DSQC 243 Serial measurement board
ABB 3HAA3563-ACA DSQC 245 Serial measurement board
ABB 3HAA3563-AAA DSQC 248 Programming board
ABB 3HAA3563-AGA DSQC 249A Rectifier
ABB 3HAA3563-AHA DSQC 249B Rectifier
ABB 3HAA3563-AD DSQC 252 System board
E3HAC028756-001 DSQC 253 SMB unit DSQC 573
E3HAA3563-AMA DSQC 253 Serial Measurement Board
E3E 042816 DSQC 253 Exch. Serial mes. DSQC 253W
6369901-218 DSQC 253 Serial Measurement Board
ABB 3HAB2211-1 DSQC 256A System board
ABB 3HAA3563-AUA DSQC 258 Power supply
ABB 3HAB8797-1 DSQC 266B Drive unit
ABB 3HAB8798-1 DSQC 266C Drive unit
ABB 3HAB8801-1 DSQC 266G Drive unit
ABB 3HAB8800-1 DSQC 266H Drive unit
ABB 3HAB8799-1 DSQC 266K Drive unit
ABB 3HAB8802-1 DSQC 266T Drive unit
ABB 3HAA3573-AAA DSQC 300 Board - Computer
ABB 3HAB2210-1 DSQC 300 Board - Computer
ABB 3HAB2233-1 DSQC 300 Board - Computer
ABB 6369901-380 DSQC 300 Board - Computer
ABB 3HAA3573-ABA DSQC 301 Programming board
ABB 3HAB2209-1 DSQC 306 Computer board
ABB 6369901-298 DSQC 306 Computer board
ABB E3HAB2209-1 DSQC 306 Computer board
ABB 3HAB3700-1 DSQC 313 Serial measurement board
ABB 3HAB4259-1 DSQC 313 Serial measurement board
ABB 3HAC9522-1 DSQC 313 Serial Measurement Board
ABB 3HAB2215-1 DSQC 314A Rectifier
ABB 3HAB2216-1 DSQC 314B Rectifier
ABB 3HAB2231-1 DSQC 314C Rectifier DC link
ABB 6369901-336 DSQC 314C Rectifier DC link
ABB E3HAB2231-1 DSQC 314C Rectifier DC link
ABB 3HAB2214-1 DSQC 315 Combi I/O
ABB 3HAB2219-1 DSQC 316 Computer board
ABB 3HAB2209-1 DSQC 317 Memory expansion board
ABB 3HAB2233-1 DSQC 322 Robot computer
ABB 3HAB5956-1 DSQC 323 Memory expansion board
ABB 3HAB5957-1 DSQC 324 Memory expansion board
ABB 3HAB2241-1 DSQC 325 Main computer
ABB 3HAB2242-1 DSQC 326 Robot computer
ABB 3HAB7230-1 DSQC 327 Analogue Digital Combi I/O
ABB 3HAB7229-1 DSQC 328 Digital 24 VDC I/O
ABB 3HAB7215-1 DSQC 331 Panel unit
ABB 3HAC17973-1 DSQC 332 Digital relay I/O
ABB 3HAB5845-1 DSQC 334 Power supply
ABB 3HAB6182-1 DSQC 335 Robot computer
ABB 3HNE00001-1 DSQC 336 Network board NIOC-01
ABB 3HAB8101-1 DSQC 345A Rectifier
ABB 3HAB8101-2 DSQC 345B Rectifier
ABB 3HAB8101-3 DSQC 345C Rectifier
ABB 3HAB8101-4 DSQC 345D Rectifier
ABB 3HAB8101-14 DSQC 345E Rectifier
ABB 3HAB8101-5 DSQC 346A Drive unit
ABB 3HAB8101-6 DSQC 346B Drive unit
ABB 3HAB8101-7 DSQC 346C Drive unit
ABB 3HAB8101-11 DSQC 346E Drive unit
ABB 3HAB8101-8 DSQC 346G Drive unit
ABB 3HAB8101-13 DSQC 346U Drive unit
ABB 3HNE00957-1 DSQC 350 Remote I/O
ABB 3HNE00065-1 DSQC 354 Encoder interface
DSQC 355 I/O Board
ABB 3HAB8101-10 DSQC 358C Drive unit / Rectifier
ABB 3HAB8101-12 DSQC 358E Drive unit / Rectifier
ABB 3HAB8101-15 DSQC 358F Driveunit / Rectifier
ABB 3HAB8101-16 DSQC 358G Drive unit / Rectifier
ABB 3HAC0373-1 DSQC 361 Main computer
ABB 3HAC1462-1 DSQC 363 Robot computer
ABB 3HAC1620-1 DSQC 365 Power supply
ABB 3HAC3180-1 DSQC 373 Robot computer
ABB 3HAC3462-1 DSQC 374 Power supply
ABB 3HAC10597-1 DSQC 386 Devicenet gateway
ABB 3HAC3616-1 DSQC 500 Main computer
ABB 3HAC3619-1 DSQC 503 Axis computer
ABB 3HAC4297-1 DSQC 506 Power supply
ABB 3HAC5393-2 DSQC 508 Battery unit
ABB 3HAC5687-1 DSQC 509 Panel unit
ABB 3HAC7519-2 DSQC 518A Flash disk 64Mb
ABB 3HAC7519-3 DSQC 518B Flash disk 128Mb
ABB 3HAC8848-1 DSQC 522 I/O computer board
ABB 3HAC12158-1 DSQC 532 I/O Computer
ABB 3HAC14265-1 DSQC 539 Power supply
ABB 3HAC14279-1 DSQC 540 Main computer
ABB 3HAC16917-3 DSQC 544A Flash disk 64Mb
ABB 3HAC16917-4 DSQC 544B Flash disk 128Mb
ABB 3HAB8101-19 DSQC 545A Rectifier
ABB 3HAB8101-18 DSQC 546A Drive unit
ABB 3HAC17396-1 DSQC 562 Serial measurement board
ABB 3HAC022104-001 DSQC 564A Flash disk 64Mb
ABB 3HAC022104-002 DSQC 564B Flash disk 128Mb
ABB 3HAC020466-1 DSQC 627 Power supply
ABB 3HAC025918-001 DSQC 653 Digital relay
ABB 3HAC025465-004 DSQC 656 Flash disk 256Mb
ABB YB560103-BD DSQC223 I/O Card
ABB YB560103-BL DSQC228
ABB YB560103-CA DSQC236A DriveUnit
ABB 3HAA 3562-AGA/2 DSQC249A PowerUnit
ABB 3HAA 3563-ALA/2 DSQC252
ABB 3HAB 2211-1/1 DSQC256A
ABB 3HAB2213-1/3 DSQC313
ABB 3HAB6372-1 DSQC330 S4C Rechner Rack
ABB 3HAB7215-1/07 DSQC331 S4C Safety Board
ABB cable DSQC352 Profibus
ABB cannot find pn DSQC355 Analogbaugruppe
ABB YB161100-DP DSQS 174 Teach pendant S2
ABB YB161100-DR DSQS 174 Teach pendant S2
ABB 48990001-FE DSSR 115 Power supply
ABB 48990001-FK DSSR 116 Power supply
ABB 3HAC023195-1 Flexpendant Teach pendant IRC5
ABB 3HNE00313-1 TPU
YT212 002-A Rectifier
YT212 002-X Rectifier
ABB YT213001-BA YTE 102A Drive unit
ABB YT213001-BB YTE 102B Drive unit
ABB YT213001-BB YTE 102B Drive unit
ABB YT213001-BC YTE 102C Drive unit
YT213001-AC YTE 102C Drive
6369901-182 YTE 102C
EYT213001-BC YTE 102C
ABB YT212001-AF YTEA 250-15 Drive unit
ABB YT212001-AE YTEA 250-8 Drive unit
ABB YT212001-AB YYE 109A Power supply
ABB YT212001-AC YYT 102A Servo board
ABB YT212001-AD YYT 102B Servo board
ABB YT212001-AK YYT 102C Servo board
ABB YT212001-AT YYT 102D Servo board
ABB YT212001-AM YYT 102E Servo board
ABB YT212001-AN YYT 102F Servo board
ABB YT212001-AP YYT 102G Servo board
ABB YT212001-AR YYT 102H Servo board
ABB YT212002-AD YYT 107A Rectifier
Kuka 96 Roboter IR365/10 Langarm
Kuka 93 Roboter IR364/10/15
Kuka 98/99 Roboter KR125-2, 150, L150
Kuka 96 Roboter VKR125-1
Kuka 99 Roboter VKR125-2, VKR150
Kuka -00 Druckausgleich GA2-D.2
Kuka 96 VKRC1 Controller
Kuka 2000 VKRC1 Controller
Kuka 98/99 KRC1 Controller
Kuka 2000 KRC1 Controller
Kuka like new KRC1 Separat Controller Top
Kuka KRC1 Separat Controller Top
Kuka RC30/51c Controller
Kuka 71-052-214 MFC KRC1
71-039-272 with DSEAT
Kuka 00-117-336 DSE-IBS-C33
Kuka 71-039-271 RDW KRC1
Kuka 71-051-224 Motorleitung KRC1 7m
Kuka 71-051-225 Motorleitung KRC1 15m
Kuka Motorleitung KRC2 7m Serie2000
Kuka 00-106-496 Geberleitung KRC1/2 7m
Kuka 71-051-222 Geberleitung KRC1/2 15m
Kuka 00-127-94 Geberleitung KRC1/2 25m
Kuka 69-327-924 KRC32, PS15/67I
Kuka 69-327-921 KRC32, 3PS15/67I
Kuka 69-334-285 KRC32, NM100ABN
Kuka 69-223-650 KRC32, FE001/1
Kuka 69-223-653 KRC32, FE002/1-2
Kuka SEF 1b TP
Kuka 6FR2490-0AH12 KCP32 TP
Kuka 69-000-398 KCP1 TP
Kuka 00-110-185 KCP2 TP
Kuka 00-130-547 KCP2 TP
Kuka 69-000-399 VKCP1 TP
Kuka 00-107-264 VKCP2 TP
Kuka 00-132-347 KCP2
Kuka 6FX1404-0CC20 KCP32
Kuka 6FX1404-0CC10 KCP32 KUKA KCP2-00-110-185
Fanuc A05B - 2301 - 335
Fanuc TP Leitung
Fanuc EE-5188-201-014
Fanuc EE-5188-208-014
KSD1-16
KSD1-48
KSD1-32
KSD1-64
KSD1-08
KPS-600/20-ESC
KUKA KRC2 KSD1-48
KUKA KRC2 KSD1-32
KUKA KCP2-2005
DSQC 609 3HAC14178-1 1pcs
DSQC 662 3HAC026254-001 1pcs
DSQC 661 3HAC026253-001 2pcs
DSQC 652 3HAC025917-001 2pcs
DSQC 651 3HAC025784-001 2pcs
DSQC 655 3HAC025562-001 1pcs
4周
DSQC 328A 3HAC17970-1
DSQC 611 3HAC13389-2
DSQC 608 3HAC12934-1
DSQC 604 3HAC12928-1
DSQC 602 3HAC12816-1
DSQC 601 3HAC12815-1
DSQC 658 3HAC025779-001
DSQC 643 3HAC024488-001
DSQC604
DSQC 604
3HNE00313-1
3HAC14279-1/04 DSQC 540
DSQC679 3HAC028357-001
1. 視教器 3HAC028357-001
2. 電源 3HAC025917-001/00
3.伺服控制器 3HAC17282-1/07A
4.伺服控制器 3HAC14657-2/06A
5.伺服控制器 3HAC14549-3/12A
6.伺服控制器 3HAC14550-4/08A
7.伺服控制器 3HAC17281-1/03A
8.伺服控制器 3HAC025338-006/08A
9.QSDC652,10模塊 3HAC026253-001
ABB 3HAB8101-11
ABB 3HAC14363-1
ABB 3HAC18159-1
ABB 3HNE00442-1
ABB 3HNE03277-1
ABB 3HNE06225-1
3HNE00314-1
3HNM07686-1
3HNM07485-1
8 PLC-數字I/0模塊 24VDC/1A DIO216 個 1
9 PLC-溫度記錄模塊 24VDC PTAI216
PLC模塊/通訊RS204
PLC模塊/網口EM203
PLC模塊DI232
PLC模塊DO232
角度控制元件 ISI222
PLC快速數據總線模塊FM211
PLC數字輸入輸出模塊DIO216
PLC模塊CM202
光纖傳輸接口模塊 FS211/N
人機界面(觸摸屏)|WT205 LX700/DD256/CF512/VX
巴赫曼人機界面（觸摸屏）WT205 LX800/DD512/CF512/VX
巴赫曼人機界面(觸摸屏)|WT205 LX700/DD256/CF512/VX||
巴赫曼WT205/T/BE1/LX7人機界面
24V電源模塊 NT255
MPC240控制器 MPC270
數字量輸入輸出模塊 DIO280
數字量輸入輸出模塊 DIO232
模擬量輸入輸出模塊 AIO288
DP模塊 DPM200
背板 BS212
編碼器模塊 IS1202/IS1222
FAST-BUS 模塊 FM211
風機PL模塊ISI222 機艙
風機PL模塊MX213 機艙
風機PL模塊FM211 塔基
Yaskawa JUSP-NS500
在線咨詢 
