Siemens RWR490.40/MCQ D14系列德國CRANE截止閥的啟閉件是塞形的閥瓣，密封上面呈平面或海錐面，閥瓣沿閥座的中心線作直線運動。閥桿的運動形式，（通用名稱：暗桿），也有升降旋轉桿式可用于控制空氣、水、蒸汽、各種腐蝕性介質、泥漿、油品、液態金屬和放射性介質等各種類型流體的流動。因此，這種類型的截流D14系列德國CRANE截止閥閥門非常適合作為切斷或調節以及節流用。由于該類閥門的閥桿開啟或關閉行程相對較短，而且具有非常可靠的切斷功能，又由于閥座通口的變化與閥瓣的行程成正比例關系，非常適合于對流量的調節。
D14系列德國CRANE截止閥維護方法
D14系列德國CRANE截止閥各種閥件應齊全、完好。法蘭和支架上的螺栓不可缺少，螺紋應完好無損，不允許有松動現象。手輪上的緊固螺母，如發現松動應及時擰緊，以免磨損連接處或丟失手輪和銘牌。截止閥的手輪如有丟失，不允許用活扳手代替，應及時配齊。填料壓蓋不允許歪斜或無預緊間隙。對容易受到雨雪、灰塵、風沙等污物沾染的環境中的截止閥，閥桿要安裝保護罩。截止閥上的標尺應保持完整、準確、清晰。截止閥的鉛封、蓋帽、氣動附件等應齊全完好。不允許在運行中的截止閥上敲打、站人或支承重物;特別是非金屬閥門和鑄鐵閥門，更要禁止閥門注脂時的維護保養工作在焊接前投產前以及投產后的閥門專業養護工作，為閥門服務于生產運營中起著至關重要的作用，正確和有序有效的維護保養會保護閥門，使閥門正常發揮功能并且延長閥門使用壽命。閥門養護工作看似簡單，其實不然。工作中常有被忽視的方面。
一、D14系列德國CRANE截止閥注脂時，常常忽視注脂量的問題。注脂加油后，操作人員選擇閥門和注脂聯結方式后，進行注脂作業。存在著二種情況：一方面注脂量少注脂不足，密封面因缺少潤滑劑而加快磨損。另一方面注脂過量，造成浪費。在于沒有根據閥門類型類別，對不同的截止閥密封容量進行計算。可以以截止閥尺寸和類別算出密封容量，再合理的注入適量的潤滑脂。
二、D14系列德國CRANE截止閥注脂時，常忽略壓力問題。在注脂操作時，注脂壓力有規律地呈峰谷變化。壓力過低，密封漏或失效，壓力過高，注脂口堵塞、密封內脂類硬化或密封圈與閥球、閥板抱死。通常注脂壓力過低時，注入的潤滑脂多流入閥腔底部，一般發生在小型閘閥。而注脂壓力過高，一方面檢查注脂嘴，如是脂孔阻塞判明情況進行更換;另一方面是脂類硬化，要使用清洗液，反復軟化失效的密封脂，并注入新的潤滑脂置換。此外，密封型號和密封材質，也影響注脂壓力，不同的密封形式有不同的注脂壓力，一般情況硬密封注脂壓力要高于軟密封。球閥維護保養時一般都處于開位狀態，特殊情況下選擇關閉保養。其他閥門也不能一概以開位論處。閘閥在養護時則必須處于關閉狀態，確保潤滑脂沿密封圈充滿密封槽溝，如果開位，密封脂則直接掉入流道或閥腔，造成浪費。
D14系列德國CRANE截止閥安裝后，應定期進行檢查，主要檢查項目：
（1）截止閥密封面磨損情況。
（2）閥桿和閥桿螺母的梯形螺紋磨損情況。
（3）填料是否過時失效，如有損壞應及時更換。
（4）D14系列德國CRANE截止閥檢修裝配后，應進行密封性能試驗。
D14系列德國CRANE截止閥操作
對于截止閥，不但要會安裝和維護，而且還要會操作。
啟閉截止閥，用力應該平穩，不可沖擊。某些沖擊啟閉的高壓截止閥各部件已經考慮了這種沖擊力與一般截止閥不能等同。
當D14系列德國CRANE截止閥全開后，應將手輪倒轉少許，使螺紋之間嚴緊，以免松動損傷。
管路初用時，內部臟物較多，可將截止閥微啟，利用介質的高速流動，將其沖走，然后輕輕關閉（不能快閉、猛閉，以防殘留雜質夾傷密封面），再次開啟，如此重復多次，沖凈臟物，再投入正常工作。
常開截止閥，密封面上可能粘有臟物，關閉時也要用上述方法將其沖刷干凈，然后正式關嚴。
如手輪、手柄損壞或丟失，應立即配齊，不可用活絡板手代替，以免損壞閥桿四方，啟閉不靈，以致在生產中發生事故。
某些介質，在D14系列德國CRANE截止閥關閉后冷卻，使閥件收縮，操作人員就應于適當時間再關閉一次，讓密封面不留細縫，否則，介質從細縫高速流過，很容易沖蝕密封面。
D14系列德國CRANE截止閥操作時，如發現操作過于費勁，應分析原因。若填料太緊，可適當放松，如閥桿歪斜，應通知人員修理。有的截止閥，在關閉狀態時，關閉件受熱膨脹，造成開啟困難；如必須在此時開啟，可將閥蓋螺紋擰松半圈至一圈，消除閥桿應力，然后板動手輪。
Siemens RWR490.40/MCQ
Juniper Networks M7IBASE-AC-1GE M7i Base Router
Comes Loaded Up Real Nice - See Listing for Specs
One-day shipping available
Enlarge
Juniper Netscreen Secure Access 5000 NS-SA-5000
NS-SA-5000A-UPG-CL-2PLUS - Free Shipping!
JUNIPER NETWORKS PE-1OC48-SON-SMLR 1PORT PIC PULL
USED PULL TESTED 90 DAY WARRANTY
NEW JUNIPER EX4200-24T Juniper EX4200-24T Layer 3 Switc
NEW JUNIPER EX-SFP-1GE-LH Juniper 1000Base-LH SFP Modul
Juniper PB-1GE-SFP-QPP - 1-Port Gigabit Ethernet w/ QPP
One-day shipping available
3x PB-1OC48-SON-SFP Juniper T320, T640 STM16 OC48
NEW N BOX JUNIPER NETSCREEN NS-204-001 FIREWALL NETWORK
Juniper PE-1OC12-ATM2-MM M10i, M10, M7i, M5 Warranty
Juniper Networks M7i Wired Router
Juniper M320 M320BASE-EC-AC Router RE-1600-2048
Juniper PB-2GE-SFP-QPP Gigabit Ethernet PIC 1000Base-X
Juniper PB-LS-128 Link Services PIC, M160 M40E
SHIPS TODAY! *Fully Tested* 1 YR WRNTY! 2+ Avail
One-day shipping available
Juniper PB-10CHT1-RJ48-QPP for M40e/M320 Warranty
Juniper P-1OC12-ATM2-SMIR Module GF
Juniper T640-FPC3 Flexible PIC Concentrator T640
1 Year Warranty - No Reasonable Offers Ever Refused!
Agilestar - EX-XFP-10GE-ZR - Juniper - New in Box
Juniper ERX CT3-12-F0 NGI2KLGEAA Channelized T3
90 Day Warranty - Free Overnight Shipping
Juniper Netscreen NS-5000-2XGE 5200 5400 Firewall 10G
90 Day Warranty - Free Shipping!
Juniper NS-ISG-2000
Juniper DX-3650-S-4G Application Accelerator 4x 1000bT
90 Day Hardware Warranty - Free Shipping!
Juniper M20BASE-AC 2x FPC 2x P-1GE-SX 2x SSB-E 2x RE333
Juniper DX 3680 Load Balancer DX-3680-SLB-SSL-S-4G
90 Day Hardware Warranty DX-3680-SLB-SSL-S-4G
Juniper DX-3600-SLB-SSL-N-4G-A DX3600 Load Balancer
90 Day Warranty - Free Shipping!
Juniper RE-1600-2048 for M320/T320/T640 Warranty
Juniper PB-1CHOC3-SMIR-QPP 1-Port Channelized OC3 PIC
90 Day Warranty - Free Overnight Shipping!!
New JUNIPER NETWORKS: SSG-550M-SH
Juniper Networks RE-850-1536 Routing Engine 850 RE-850
Juniper RE-850-1536-S Routing Engine for M7i M10i RE850
90 Day Hardware Warranty - Free Shipping!
Agilestar - XENPAK-1XGE-ZR - Juniper - New in Box
Juniper EX 4200 24T - Switch - L3 - managed EX4200-24T
Brand New & Ready To Ship From A US Authorized Reseller
Juniper M7iBASE-AC-2FE M7i Router RE-400 M7i JUNOS 8.5
90 Day Warranty - Free Shipping!
Juniper M20BASE-DC 2x FPC 2x P-1GE-SX 2x SSB-E 2x RE333
Juniper SSG-550M-SH 1GB DRAM Unlimited Users SSG 550M
90 Day Warranty - Free Shipping!
Juniper DX-3680-SLB-SSL-S-4G Server Load Balancing SSL
Juniper PE-1OC48-SON-SFP PE-10C48-SON-SFP M7i M10i GF
Juniper Netscreen NS-IDP-200 Intrusion Prevention NEW
Juniper Netscreen NS-500 ES Adv Firewall 500es GB2 GigE
Advanced 5.4r20 OS +4 gig ports+4sx *Loaded*AC/DC combo
Juniper EX4200-24T -Juniper EX4200-24T Layer 3
Includes 2 Year Replacement Warranty
NEW JUNIPER EX3200-48T Juniper EX3200-48T Layer 3 Switc
Juniper CHAS-BP-M40E-S
Expedited shipping available
NEW Juniper SCB-MX960-S Switch Control Board 710-021523
One-day shipping available
Juniper ISG-2000 Advanced Model NS-ISG-2000 6.1.0r2.0
90 Day Warranty - Free Shipping!
Juniper M7iBASE-AC-2FE M7i RE-400 Cfeb 2X AC PWR.
Juniper PE-1CHSTM1-SMIR M10/M5 Warranty
New Juniper SSG-350M-SH
Juniper M320 M320BASE--EC AC Router RE-1600-2048
JUNIPER SCB-MX960-S switch control board MX240 MX480 MX
Juniper PE-10CHT1-RJ48-QPP
Juniper M40eBASE-DC or AC M40e Base Router
Juniper PB-1OC48-SON-SFP Juniper T320, T640 STM16 OC48
PB-1OC48-SON-SFP Juniper T320, T640 STM16 OC48
Juniper M7i Router M7iBASE-AC-2FETX w/ RE-400
JUNIPER EX4200-24T 24-port 10/100/1000BaseT(8poe)
Juniper PB-2GE-SFP-QPP Gigabit Ethernet PIC 1000Base-X
Expedited shipping available
Juniper M320 M320BASE-DC Router RE-1600-2048
Juniper M40eBASE DC or AC M40e
Juniper PB-2GE-SFP-QPP Gigabit Ethernet PIC 1000Base-X
Juniper PB-MS-100-1 PB MS 100
Juniper PB-4OC3-SON-SMIR T320/M160/M40e/M320
Juniper T320 T320-FPC3
Expedited shipping available
Juniper NS-5400-DC NS 5400 1X MGT2 1X 8G2 All SFPs GF
JUNIPER NS-IDP-600C INTRUSION DETECTION APPLIANCE
One-day shipping available
39"(h)California juniper bonsai tree, pot 16" trunk
JUNIPER IB-OC192-SON-SR2 SONET/SDH STM-64/OC-192 M160
Agilestar - XFP-10G-Z-OC192-LR2 - Juniper - New in Box
Juniper Networks PE-2MCDS3 Multichannel DS3 PIC
Juniper M7iBASE-AC-2FETX Multiservice Edge Router M7i
Juniper Intrusion Detection and Prevention IDP75 1YR
1 Year Warranty, Novia Networks 763-208-6495
JUNIPER NETWORKS PB-2OC12-ATM2-MM PIC REFURBISHED
Juniper PB-4OC3-SON-SMIR T320/M160/M40e/M320 Warranty
Juniper PB-1GE-SFP-QPP IQ QPP version
Juniper ISG-1000 Firewall Advanced Gateway IDP
90 Day Warrany - Free Shipping!
Juniper M20BASE-AC 2xRE333 2xP-1GE-SX 2xSSB-E 2x FPC-E
XFP-10G-E-OC192-IR2 NEW BULK JUNIPER OEM 740-014290
JUNIPER IDP1100C - WARRANTY - SB!
New Juniper DX-3200-N-2C HTTP Application Accelerator
90 Day Warranty - Free Shipping!
Juniper Network M160 Chassis-DC
Juniper CHAS-MP-M10i-S Spare M10i Router Chassis
90 Day warranty - Free Shipping!
Juniper M20 Router 14x P-4DS3 1x P-1GE-SX 1x P-4FE-TX
90 Day Warranty - Free Shipping!
Juniper M20 Router P-4DS3 P-4OC3 P-4FE-TX P-4OC3-SON-SM
Juniper Netscreen NS5400 NS-5000-8G, 2x NS-5000-2G24T
90 Day Warranty - Free Shipping!
Juniper DX 3650 Load Bal DX-3650-SLB-SSL-S-2G2F
DX-3650-SLB-SSL-S-2G-2F - Free Shipping
Juniper PE-2MCDS3 2-port Multichannel DS3 PIC M7i M10i
90 Day Warranty - Free Shipping!
NEW JUNIPER J-4350-JB-SC Juniper J4350 Services Router
Juniper EX4200-24T -Juniper EX4200-24T Layer 3
great seller / free shipping / great service!!!
NEW JUNIPER J2350-JH Juniper J2350 Services Router
Juniper Allegro MX + Carlson SurvCE 2 Survey Software
Juniper ERX GE/FE-8 FE_8_I/O Cardset ERX310 710 1410
90 Day Warranty - Free Shipping!
Juniper PB-2GE-SFP Type2 2-Port Gigabit Ethernet PIC
90 Day Warranty - Free Overnight Shipping!
Juniper WXC-590 Application Acceleration Platform 1000T
90 Day Warranty - Free Shipping - Make Offer!
Juniper DX-3250SLB-SSL-S-2C Load Balancer App Accel
90 Day Warranty - Free Shipping If You Buy it Now
HA pair Juniper Netscreen NS-208 Adv Firewall VPN 25/50
Firmware 5.4 r19, remote client,unlimited users,1YR wty
NEW JUNIPER SSG-350M-SH Juniper SSG 350M Security Appli
NEW Juniper EX-XFP-10GE-LR Trnscr Module 1YearWrn 2XAvl
JUNIPER SRX240H-POE SRX 240 16 x GE w/ POE
JUNIPER M7IBASE-AC-1GE M7i router w RE-400 E-FEB 1 AC
Juniper EX4200-48T L2/L3 virtual chassis switch
Tested with Warranty! ***Call (415) 483-1190 ***
One-day shipping available
Enlarge
Juniper Networks CHAS-MP-M10i-S M10i Chassis Spare
Juniper Netscreen NS-5400-AC NS 5400 MGT2 8G2 SFP GF
Juniper P-1GE-SFP-QPP Module M10 M20 GF
NEW JUNIPER EX-XFP-10GE-LR Juniper 10GBase-LR XFP Modul
PE-1CHSTM1-SMIR-QPP M10i M7i M5 M10 Juniper IQ PIC STM1
Juniper J6300 Router 2x JX-1DS3 1x JX-2FE-TX
45 Day Warranty - Free Shipping!
Juniper Netscreen NS-5000-MGT2 5000-M2 Module GF
Juniper Networks (SRX240H-POE) SRX240 Services Gatew...
Buy this product now!
One-day shipping available
NEW JUNIPER EX3200-24T-DC Juniper EX 3200-24T-DC Ethern
Juniper P-1CHSTM1-SMIR M20/M40 Warranty
NEW JUNIPER SRX240H-POE Juniper SRX240 Services Gateway
NEW JUNIPER EX2200-48P-4G Juniper EX2200-48P-4G Etherne
Juniper P-12FE-TX M20/M40 Warranty
JUNIPER PB-2GE-SFP-QPP 2-Port Gigabit Ethernet IQ PIC
IB-OC192-SON-SR2-E JUNIPER M160 ENHCD OC192 IPOL3F4DAA
One-day shipping available
Juniper PB-1CHOC3-SMIR-QPP-B 1 Port Channelized OC3 PIC
1 Port Channelized OC3 PIC - 1 Year Warranty
One-day shipping available
在線咨詢 
